| Q&A Home | Browse | Submit Your Question |
Foretravel Technical Q&A
Section: Chassis General
Q: Hi, i have a 1979 Foretravel 33´on a Dodge M600 chassis and i need a new steering gear (new or used). Any suggestion on where to find one?
A: I would suggest speaking with Mike in parts and he may have a lead for you. 800-955-6226 ext.154
Q: Hi, can you tell me what engine the 2002 U-320 36ft has in it ? All so what Version of the Allison 3000 or 4000 ? I am looking at purchasing it so if you can please answer my question I would appreciate it. Thanks, Bob
A: The coach has an ISM-450 hp. with the Allison 4000MHR.
Q: What is the wheelbase on a 2007 Nimbus 36 feet?
A: 228 inches
Q: I just purchased a 1986 Grand Villa and the fuel gauge doesn't work. I checked the gauge and it appears there is nothing wrong with it. What else can be wrong and if it's the sending unit can I get it out without dropping the tank. Thank You in advance Dennis Mitchell
A: Sounds as if the sending unit has gone bad. To access the sending unit you will have to drop the tank.
Q: Recent posts on the Yahoo Foretravel forum reported on this subject. I can't figure out if I need to worry about this or not on my '03 U320, Unit 6093. jerry
A: March 22, 2007 To: All Foretravel Dealers and Authorized Service Centers Foretravel Website From: Foretravel Motorcoach Company Mark Harvey, Warranty Director (936) 564-8367, extension 237. Subject: Retarder Accumulator Bracket Weld Inspection Foretravel has become aware of an issue where a weld on the transmission retarder accumulator mounting bracket may fail due to bracket damage or fatigue. The “only” affected coaches are year model 1998 through 2007 with 450 or 500 hp Cummins M11 or ISM engines having the retarder accumulator mounted to the engine bell housing. The accumulator is mounted to a ¼” X 5” plate approximately 12 ½” long, this plate is welded to a horizontal mounting tab from underneath, and this tab is then bolted to the engine bell housing allowing for mounting of the bracket and accumulator. When these particular coaches are being serviced in your shop the bracket should be inspected for cracking or damage in the bottom weld area. It will take less than 15 minutes to inspect. As a courtesy, Foretravel will provide the inspection at no charge to the customer in your shop. If there are signs that the bracket should be replaced, and the coach is under warranty, Foretravel will supply a new mounting bracket and labor to replace at no charge to the customer. Call Foretravel Technical Services (936) 564-8367, extension 259 or 237 for prior approval before replacing bracket. If non-warrantable replacement is needed the bracket (Part # P23439SVC) can be ordered directly from Foretravel Parts Dept. The approximate retail price of the bracket is $67.00. It will take approximately 45 minutes to replace. The customer will be responsible for non-warrantable replacement parts and labor. Customers wanting to know if your coach needs inspection or you are unable to conveniently take your coach to a Foretravel Authorized Service Center for inspection should contact Foretravel Technical Services (936) 564-8367, extension 259 or 237 for assistance.
Q: What is the maximum tongue weight from a trailer to the hitch on a 2000 36ft. U295?
A: A maximum tongue load of 1000 pounds and trailer weight of 10,000 pounds should not be exceeded. You can find this info in section four page twelve of the owner’s manual.
Q: What is the front axle rating on the 2009 40 Ft Phx?
A: The Independent Front Suspension is rated at 18,000 lbs.
Q: What is the GVWR of a 1999 40 ft U320?
A: The listed rating is: 34880
